Filters / Separators
Aviation / Diesel Cartridges
OCV Control Valves
Aircraft Nozzles /
Small Filter Housings
Item # VF-62 (32.5" height)
Item # VF-62 (32.5" height), Small Filter Housings
Email This Page
Save To Favorites
Clean Dry Fuels and Oils with High Performance
These filter housings are versatile housings designed for use with several different high performance
and other filter cartridges.
cartridges filter out water by chemically locking it into layers of super-absorbent media. Water capacity is as much as 11/2 quarts, depending on the specific vessel and cartridge. These cartridges also effectively filter out dirt, rust and other particulates. (See caution, back cover.)
cartridge reaches its water-holding limit, the media expands very rapidly and restricts the flow. The pressure drop will rapidly increase, signaling the need to change cartridges.
The VF-61, with ACO series cartridges installed, has become the standard for low flow rate full flow aviation fuel monitor applications.
Wide variety of applications
Free and emulsified water to less than 5 ppm
1/2 micron particulate removal
Provides protection against “slugs” of water
Pressure increase signals cartridge change
Over Pressure Protection
When exposed to a high concentration of water, the differential pressure across an absorbent cartridge (AC, ACO, AD, or ASL Series cartridges) will immediately increase. Pressure bypasses or other means to limit the inlet pressure to 75 psi (5 bar) should be installed to prevent cartridge from collapsing.
For aviation and diesel fuel applications, always install a differential pressure gauge or other means of determing differential pressure.
See Data Sheet for Absorbent cartridge (AC, AD) flow rates.
See Data Sheet for paper filter (FO) flow rates, synthetic filter (FOS) flow rates.
Also available: VF-61UL Filter Housing, for diesel fuels. Recognized under the Component Recognition Program of Underwriters Laboratories Inc.
Bolted, 4 bolts
1 1/2" NPT
Max. Operating Pressure
Cast aluminum head, carbon steel shell with epoxy powder coated exterior & interior
Product being filtered
Jet Fuel & Avgas
P/N 10678 - (Differential pressure gauge assembly)
P/N 554Y020 - (Carbon steel 1/2" NPT ball valve, with mounting nipple)
P/N CK-1488 (Quick release hand bolts)
1 ea P/N G-0986 Buna-N O-ring
2 ea P/N G-0986A Viton O-rings (If using with gasoline/solvent applications)
6 ea replacement filter cartridges
1 ea P/N G-0986 Buna-N O-ring
1/8” brass petcock vent valve, installed
1/2” drain plug, installed
1 ea 1/2” petcock drain, shipped loose
Selected Solvents Oils: Insulating, Hydraulic, Lubricating Compressed Air and Other Gasses
To protect the fuel system, including the VF-609 and other components, be sure to install pressure relief valve(s).
Do not use absorbent cartridges (ACO-xxxxxL, AC-xxxxx, AD-xxxxx) with pre-mixed jet fuel or avgas containing anti-icing additives.
Filter Cartridge Selection Table
VF61 Connected to Diesel Fuel Dispenser
Data Sheet for Absorbent Cartridge
Paper Filter (FO) Flow Rates
Synthetic Filter (FOS) Flow Rates
Filtration Corporation of America
| 1118 Hill Avenue, Glen Ellyn, IL 60137 | Ph: 630.858.9030 | Fx: 630.858.0953
Site created by
ThomasNet Web Solutions